Product ID:68.928 RUSTGUARD HEAVY DUTY GLOSS ENAMEL
MSDS Date:08/25/1992
FSC:8010
NIIN:00F039408
MSDS Number: BWYJN

Emergency Phone: 404-455-7000

Info Phone: 404-455-7000

Cage: WATTL

Telephone: 404-455-7000

Cage: WATTL

STODDARD SOLVENT (PETROLEUM DISTILLATE), MINERAL SPIRITS

CAS: 8052-41-3

RTECS: WJ8925000

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: ANESTHETIC. IRRITATION OF
THE RESPIRATORY TRACT/NERVOUS SYSTEM DEPRESSION. SKIN/EYES: PRIMARY
IRRITATION. OVEREXPOSURE MAY CAUSE RESPIRATORY/SKIN SENSITIZATION.
PERMANENT CNS CHANGES DUE T O SOLVENT OVEREXPOSURE HAVE BEEN
REPORTED.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, HEADACHE, DIZZINESS, STAGGERING
GAIT, CONFUSION, UNCONSCIOUSNESS, COMA

First Aid:INHALATION: REMOVE FROM EXPOSURE. RESTORE BREATHING. TREAT
SYMPTOMATICALLY. EYES: FLUSH IMMEDIATELY FLUSH W/LARGE AMOUNTS OF
WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. INGESTION: DRINK 1-2
GLASSES OF WATER TO DILUTE. DON'T INDUCE VOMITING. TREAT
SYMPTOMATICALLY. OBTAIN MEDICAL ATTENTION IN ALL CASES.

Flash Point:100F
Lower Limits:1
Extinguishing Media:USE NFPA CLASS B EXTINGUISHER
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
EXPOSED TO EXTREME HEAT. APPLICATION TO HOT SURFACES REQUIRES
SPECIAL PRECAUTIONS.

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. AVOID BREATHING
VAPORS. VENTILATE AREA. CONTAIN & REMOVE W/INERT ABSORBENT &
NON-SPARKING TOOLS.

Handling and Storage Precautions:DON'T STORE >120F. STORE LARGE
QUANTITIES ONLY IN BUILDINGS DESIGNED TO COMPLY W/OSHA. CLOSE
CONTAINER AFTER EACH USE. KEEP CONTAINERS TIGHTLY CLOSED.
Other Precautions:DON'T TAKE INTERNALLY.

Respiratory Protection:AREAS W/UNRESTRICTED VENTILATION USE NIOSH/MSHA
APPROVED MECHANICAL FILTER TO REMOVE OVERSPRAY. RESTRICTED AREAS,
USE APPROVED CHEMICAL/MECHANICAL FILTER. IN CONFINED AREAS, USE
APPROVED RESPIRATOR W/ EXTERNAL AIR SUPPLY.
Ventilation:SUFFICIENT IN VOLUME & PATTERN TO INSURE VAPOR
CONCENTRATIONS WELL BELOW & TLV & LEL.
Protective Gloves:NONE REQUIRED
Eye Protection:REQUIRED
Other Protective Equipment:SAFETY EYEWEAR W/SIDE SHIELDS/SPLASH GUARDS
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health

Boiling Pt:B.P. Text:300-390F
Vapor Density:>1
Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:53-70

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS
Stability Condition to Avoid:HIGH TEMPS, SPARKS, OPEN FLAME, HOT
SURFACES & OTHER IGNITION SOURCES
Hazardous Decomposition Products:CO

Waste Disposal Methods:DON'T INCINERATE CLOSED CONTAINERS. INCINERATE
IN AN APPROVED FACILITY IN ACCORDANCE W/LOCAL, STATE & FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.